FAA grounds 171 Boeing planes after mid-air blowout on Alaska Airlines jet
The US aviation regulatory authority has mandated the suspension of certain Boeing 737 Max 9 aircraft following an incident where a section of one plane detached during an Alaska Airlines flight.
The Federal Aviation Administration (FAA) declared that inspections would impact 171 planes.
An emergency landing was necessitated for an Alaska Airlines flight departing from Oregon on Friday. United Airlines has confirmed compliance with FAA inspections on some of its 79 Boeing 737 Max 9 planes.
This grounding is anticipated to result in approximately 60 flight cancellations on Saturday, according to the airline’s statement.
The FAA earlier announced the temporary grounding of specific Boeing 737 Max 9 aircraft operated by US carriers or within US territory. The required inspections are estimated to take between four to eight hours per aircraft.
The UK’s Civil Aviation Authority (CAA) affirmed the absence of UK-registered 737 Max 9 aircraft and communicated outreach to non-UK and foreign permit carriers to ensure inspections before operating in UK airspace, as shared on X, formerly Twitter.
In Friday’s incident, the Alaska Airlines flight from Portland, Oregon to Ontario, California, had reached 16,000ft (4,876m) when it began its emergency descent, according to flight tracking data.
The airline, carrying 177 passengers and crew, landed safely back in Portland.
Images sent to news outlets showed the night sky visible through the gap in the fuselage, with insulation material and other debris also seen.
There were no immediate indications of the cause of the apparent structural failure, nor any reports of injuries.
Passenger Evan Smith said: “There was a really loud bang towards the left rear of the plane and a woosh noise – and all the air masks dropped.
“They said there was a kid in that row who had his shirt sucked off him and out of the plane and his mother was holding onto him to make sure he didn’t go with it.”
In an audio clip, the pilot can be heard talking to air traffic control requesting a diversion.
“We are an emergency,” she said. “We are depressurised, we do need to return back.”
According to photographs, the affected area was in the back third of the plane, behind the wing and engines.
The section of fuselage involved appears to be an area that can be used as an additional emergency exit door by some operators, but not by Alaska.
Terry Tozer, a former airline pilot who has written extensively on aviation safety, said the section should have been bolted into place if it was not being used as an emergency exit.
He told the BBC News Channel that the passengers would not have been able to tell the area was not a normal window from inside the cabin.
While the loss of this section would probably not have affected how the aircraft flew, Mr Tozer added, there would have been a “huge risk” to anyone sitting nearby.
“Fortunately, there was nobody sitting in that window seat. Had they been unbelted, they may have well been sucked out,” he said.
Announcing the initial grounding of 65 planes, Alaska Airlines’ CEO Ben Minicucci said: “Each aircraft will be returned to service only after completion of full maintenance and safety inspections.”
A later statement said that more than a quarter of those planes had been inspected and would return to service as there were no issues found.
In a statement, Boeing said it supported the FAA’s decision. and was co-operating with the National Transportation Safety Board’s investigation of the Alaska Airlines incident.
“Safety is our top priority and we deeply regret the impact this event has had on our customers and their passengers,” Boeing said.
It is the latest problem involving Boeing’s best-selling model, which was grounded for almost two years following crashes in 2018 and 2019.
